November 1989 CONSUMERS' QUESTIONS AND ANSWERS Refrigerants and the Atmosphere This information is provided as a public service by the Refrigeration Service Engineers Society and your heating and air conditioning service contractor. It is intended to provide clear, factual answers to questions about stratospheric ozone depletion, what is being done about it, and how the situation will affect you. Q: WHAT IS OZONE? Ozone is a gas. It consists of three atoms of oxygen in each molecule; the oxygen we breathe contains two atoms in each molecule. Chemically, oxygen is O2, and ozone is O3. The *ozone layer* consists of ozone in the stratosphere, high above the earth at an altitude of between 7 and 28 miles. It is formed by ultraviolet light from the sun acting on oxygen molecules. The ozone layer absorbs and scatters ultraviolet light from the sun, preventing harmful amounts of ultraviolet from reaching the earth. For this reason, it is often referred to as the Ozone Shield. Q: BUT ISN'T OZONE UNHEALTHFUL? Yes, when it occurs in the lower atmosphere where we breathe it. This is caused by ultraviolet radiation from the sun acting on smog and air pollutants on hot Summer days. This situation should not be confused with the protective ozone layer in the stratosphere. Ozone at ground level is a harmful pollutant; in the stratosphere it is a protective shield. WHAT ARE CFCs? *chlorofluorocarbon*; chemicals that CFC stands for contain chlorine, fluorine and carbon, and may contain hydrogen. These chemicals are inexpensive, safe, non-flammable refrigerants of high thermal efficiency. They are also used as solvents in cleaning electronic microcircuits, and as the blowing agent in manufacturing foam insulations. There are some other uses, as well. In many other countries, CFCs are still used as aerosol propellants. CFC is the general term often used inaccurately for all these compounds. It is important to realize that not all *CFCs* are equally suspected of affecting the atmosphere. CFCs which contain chlorine but no hydrogen (fully halogenated CFCs) are the real problem. Those which contain no chlorine, only fluorine (HFCs), and those which contain hydrogen along with chlorine (HCFCs), have a far smaller effect, if any at all. Q: WHAT DO CFCs DO TO THE OZONE LAYER? Certain chlorine-containing refrigerants are so stable that they do not break down in the lower atmosphere, even a hundred years or more after being released. These chemicals gradually float up to the stratosphere, where the chlorine reacts with ozone, causing it to change back to oxygen. The chlorine is not used up in the reaction; each molecule goes on to cause more and more ozone-to-oxygen reactions. Q: ARE THERE OTHER CHEMICALS THAT HAVE THE SAME EFFECT? Yes; bromine-containing compounds, such as contained in certain *halon* fire extinguishers, also have been implicated in potential ozone depletion. Bromine is chemically related to chlorine. Q: WHAT IS THE RESULT? Depletion of the ozone layer could result in increased exposure to ultraviolet radiation at some point in the future. The best available scientific information indicates that proper action taken now to reduce consumption of fully halogenated CFCs should avoid possible future effects on humans and the environment. Potential effects include increases in skin cancer and cataracts, inability to resist certain infectious diseases, decreased yields of agricultural crops, and effects on marine life that is essential to the food chain. Q: WHAT IS THE *OZONE HOLE* I'VE READ ABOUT? This is a thinning in the ozone layer over Antarctica, which occurs during the Antarctic Spring season (Autumn in the Northern Hemisphere). It occurs over the Antarctic continent due to the unique climate caused by powerful circumpolar winds and extremely low temperatures there; the lowest on earth. This area is being carefully monitored for the degree to which ozone thins out, since it has been found to lead to ozone depletion in other parts of the world, as well. Significantly reduced ozone levels were detected in 1985, and high chlorine levels were found in 1986. Instrumented aircraft flights through this layer indicate that the ozone depletion problem may be more serious than initially thought. Q: DIDN'T WE STOP USING CFCs IN SPRAY CANS FOR THIS REASON? During the early 1970s, CFCs used as aerosol propellants constituted over 50% of total CFC consumption in the U.S. Following concerns initially raised by Professor Sherwood Rowland and Dr. Mario Molina in 1974, the E.P.A. and the Food and Drug Administration in 1978 banned the use of CFCs as aerosol propellants in all but a few essential applications. This use of CFCs was reduced in the U.S. by approximately 95%. Unfortunately, very few other countries followed the U.S. in this ban. Because of the many practical uses of CFCs, their production and use has now surpassed pre-1974 levels. Q: IS THIS THE SAME AS THE *GREENHOUSE EFFECT*? No, but CFCs may be involved in this problem, also. The greenhouse effect occurs when carbon dioxide (mostly form the burning of fossil fuels; oil, natural gas, and coal) and other gases (methane, nitrogen, oxides, and others) build up in the atmosphere. These gases let incoming sunlight and its heat reach the earth, but block the earth's heat from radiating into space. This is the way a greenhouse works, and so the name of the effect. As the gases build up, more heat is trapped, and the planet's temperature rises. Some scientists now feel that CFCs may also be contributing to this effect. Q: WHAT IS BEING DONE TO STOP DEPLETION OF THE OZONE LAYER? Scientists from around the world recognize the importance and severe results of this problem, and realize that all countries must cooperate to stop erosion of the ozone shield. In the Fall on 1987, representative of more than 30 nations, meeting in Montreal, Canada, signed an agreement now known as the Montreal Protocol. The U.S. and Canada were included. On August 1, 1988, the U.S. Environmental Protection Agency (E.P.A.) enacted the provisions of this agreement into regulations for the United States. The Montreal Protocol and the E.P.A. specify that as of July 1, 1989, production and consumption of certain CFCs will be limited to the levels produced and consumed in 1986. This actually means a cutback, because use has grown since that time. In July, 1993, these levels will be reduced by 20%, and to 50% of 1986 levels in July of 1998. Specifically, the chemicals involved are the fully halogenated CFCs 11, 12, 113, 114, and 115. Halons 1211, 1301, and 2402 are also covered, but on a different time schedule. Scientific, technological, and economic concerns are to be reviewed at least every four years, with the first review in 1990. The most recent technical information indicates that even deeper cuts in production and use may be necessary. The head of the E.P.A. has stated that these chemicals should be completely eliminated, and some responsible industry trade groups agree. But all is not lost when it comes to our needs for refrigerants. It's important to remember that only fully halogenated refrigerants are being phased down. The refrigerant in home refrigerators, freezers and automotive air conditioning is mostly CFC 12, one of those being regulated. But central home air conditioning typically uses HCFC 22. Over a period of time, new appliances can be redesigned to use HCFCs in place of fully halogenated CFCs. Manufacturers of electronic microcircuits uses CFCs to clean parts. They are successfully switching to other chemicals. Manufacturers of foam insulation use CFCs to produce the insulating bubbles in the insulation. There are other methods and chemicals they can used, although these produce insulation that is less efficient. New replacement refrigerators are also being developed, but these will require years of testing for any toxic effects, to make sure they are safe. Q: CAN'T WE JUST SWITCH TO SOME OF THE OTHER REFRIGERANTS? Yes, but this is going to take time. HFC and HCFC refrigerants can replace the CFCs, but the refrigeration and air conditioning equipment has to be redesigned and manufactured. The existing refrigerant in your refrigerator, as an example, cannot be simply removed and replaced with one of the other refrigerants, because the compressor, cooling coil, and other components in the system were designed for the specific refrigerant being used. Different refrigerants have different characteristics, which affect the compressor and other components in the system. A lubricating oil also has to be developed that will be compatible with the new HCFCs and HFCs. Q: HOW WILL THIS SITUATION AFFECT US? As mentioned, insulation can be manufactured using other methods and chemicals, but the result is less efficient; greater thicknesses of insulation will have to be used to get the same insulating effect. That will mean refrigerators and freezers that are either larger on the outside or smaller on the inside. Refrigerated trucks can not be make larger on the outside, of course, and so cargo capacity will be reduced. Carrying less frozen food per trip will mean somewhat higher transportation costs, which may increase some of the prices we pay. Necessary changes in the processing of frozen foods may also result in increased costs. Refrigerators, freezers, and other systems using CFC-12 that are redesigned for other refrigerants will probably be slightly less efficient, using more electricity for operation. They may also be somewhat heavier. The price your air conditioning service contractor pays for refrigerant will increase, as a result of shorter supplies. To help control these costs and make supplies go farther, your service technician will take steps to conserve, recover, and re-use refrigerants. It is increasingly important to find and repair leaks in systems, rather than just adding more refrigerant periodically. Existing residential appliances and systems should not become obsolete nor have to be replaced any sooner. Owners and operators of large commercial air conditioners and refrigeration systems will probably notice a great many more changes than the homeowner will. The more thoroughly we can prevent the escape of CFCs to the atmosphere, and the more wisely we can conserve and recycle these materials, the better we can protect our health and that of generations to come, protect the environment, and control our overall costs in the long run. This information was copied 12 October 1989 by Jerry J. Trantow Research Scientist Johnson Controls, Inc. 507 E. Michigan Street MS-36 Milwaukee, Wi 53201 out of a bulletin from: Refrigeration Service Engineers Society 1666 Rand Road Des Plaines, Illinois 60016-3552 PHONE (312) 297-6464 FAX (312) 297-5038 with permission from Dean Lewis. If you would like an original copy send a self-addressed stamped business size (#10) envelope to RSES requesting a copy of "Consumers' Question and Answers, Refrigerants and the Atmosphere". Quantities are also available, call RSES for details. The original bulletin has several color pictures of the ozone hole, chemical reactions, etc. [Remaining Text Missing]