"Red or White Powder" Propellant by the Jolly Roger "Red or White Powder" Propellant may be prepared in a simple, safe manner. The formulation described below will result in approximately 2 1/2 pounds of powder. This is a small arms propellant and should only be used in weapons with 1/2 in. diameter or less (but not pistols!). Material Required: ----------------- Heat Source (Kitchen Stove or open fire) 2 gallon metal bucket Measuring cup (8 ounces) Wooden spoon or rubber spatula Metal sheet or aluminum foil (at least 18 in. sq.) Flat window screen (at least 1 foot square) Potassium Nitrate (granulated) 2-1/3 cups White sugar (granulated) 2 cups Powdered ferric oxide (rust) 1/8 cup (if available) Clear water, 1-1/2 cups Procedure: --------- 1) Place the sugar, potassium nitrate, and water in the bucket. Heat with a low flame, stirring occasionally until the sugar and potassium nitrate dissolve. 2) If available, add the ferric oxide (rust) to the solution. Increase the flame under the mixture until it boils gently. NOTE: The mixture will retain the rust coloration. 3) Stir and scrape the bucket sides occasionally until the mixture is reduced to one quarter of its original volume, then stir continuously. 4) As the water evaporates, the mixture will become thicker until it reaches the consistency of cooked breakfast cereal or homemade fudge. At this stage of thickness, remove the bucket from the heat source, and spread the mass on the metal sheet. 5) While the material cools, score it with a spoon or spatula in crisscrossed furrows about 1 inch apart. 6) Allow the material to dry, preferably in the sun. As it dries, resore it accordingly (about every 20 minutes) to aid drying. 7) When the material has dried to a point where it is moist and soft but not sticky to the touch, place a small spoonful on the screen. Rub the material back and forth against the screen mesh with spoon or other flat object until the material is granulated into small worm-like particles. 8) After granulation, return the material to the sun to allow to dry completely. ----------------Jolly Roger